Milestone PLANK Owner First F-35C Arrest NIMITZ 03 Nov 2014

Production milestones, roll-outs, test flights, service introduction and other milestones.
  • Author
  • Message
Offline

quicksilver

Elite 2K

Elite 2K

  • Posts: 2580
  • Joined: 16 Feb 2011, 01:30
  • Warnings: 1

Unread post22 Nov 2014, 14:46

popcorn wrote:Ya think?

http://www.forbes.com/sites/lorenthomps ... -at-sea/2/



...Perhaps there is a lesson to be learned about our culture from the fact that the Navy’s very positive experience with its F-35 variant this month has gone largely unnoticed in the general media, even though every supposed problem with the plane up to this point has gotten headlines...


Media learned it long ago. Editorial rule of thumb is, "if it bleeds...it leads." Controversy sells, and in the 21st century it sells website hits (which generate advertising and justifies ad rates).
Offline

mixelflick

Elite 3K

Elite 3K

  • Posts: 3268
  • Joined: 20 Mar 2010, 10:26
  • Location: Parts Unknown
  • Warnings: 3

Unread post22 Nov 2014, 20:37

Remember when the tailhook was a "HUGE" problem?

Sure doesn't look that way anymore. The media will just move on to something else, oblivious to the fact new birds have bugs to be worked out. This is looking like the F-15 more and more now that I think about it. Early on, it was panned. Too big, too expensive, won't live up to the hype.

More than lived up to it, in fact. 105 or so kills to 0 losses, in air to air engagements.
Offline
User avatar

spazsinbad

Elite 5K

Elite 5K

  • Posts: 22984
  • Joined: 05 May 2009, 21:31
  • Location: ɐıןɐɹʇsn∀¯\_(ツ)_/¯
  • Warnings: -2

Unread post23 Nov 2014, 05:45

Towards the end of this interview (majority about the F-35B/CVF) there are questions about the F-35C and arresting the same so it is appropriate to post the same material that appears there [ viewtopic.php?f=22&t=20304&p=281943&hilit=Hipple#p281943 ] here:
Sea Control 28 (East Atlantic) – The F-35
March 2014 By LT Matthew Hipple speaking to STEVE GEORGE

"For the inaugural edition of Sea Control’s “East Atlantic” series, Alexander Clarke brings on Steve George, former engineer with the F-35 program and Royal Navy veteran to discuss the challenges and misconceptions of the F-35 program."

AUDIO: http://cimsec.org/wp-content/uploads/20 ... c-F-35.mp3 (28Mb)

Source: http://blog.usni.org/2014/03/31/sea-con ... c-the-f-35
RAN FAA A4G Skyhawk 1970s: https://www.faaaa.asn.au/spazsinbad-a4g/ AND https://www.youtube.com/channel/UCwqC_s6gcCVvG7NOge3qfAQ/
Offline
User avatar

spazsinbad

Elite 5K

Elite 5K

  • Posts: 22984
  • Joined: 05 May 2009, 21:31
  • Location: ɐıןɐɹʇsn∀¯\_(ツ)_/¯
  • Warnings: -2

Unread post24 Nov 2014, 02:00

Elsewhere there is the suggestion that the USN does not want the F-35C. So this video could go there (many places this suggestion is made however) whilst I reckon the last bit about 'carrier integration' etc. puts the video here. AND this video is more than ONE YEAR OLD so don't get huffy about that. Also the start has good bits about 'nifc-ca' ca-ca. AND... a MANAZIR oldie:
Navy Needs F-35's Capabilities, Admiral Says
Story Number: NNS100526-10 Release Date: 5/26/2010 Jim Garamone, American Forces Press Service

"WASHINGTON (NNS) -- The Navy needs the F-35 Lightning II joint strike fighter's fifth-generation capabilities, said the service's acting director of air warfare May 24.

Navy Rear Adm. Michael C. Manazir spoke to reporters because he wanted to "completely dispel the rumor that the Navy is soft on F-35C." {But ADM - no one gives a crap - right? Least of all the rumourmongers.]..."

Source: http://www.navy.mil/submit/display.asp?story_id=53637

CNO Testifies About Joint Strike Fighter
Published on Jun 19, 2013 USN

"Chief of Naval Operations Adm. Jonathan Greenert testified before the Senate Appropriations Committee Subcommittee on Defense about the Joint Strike Fighter (F-35C) on June 19, 2013."

RAN FAA A4G Skyhawk 1970s: https://www.faaaa.asn.au/spazsinbad-a4g/ AND https://www.youtube.com/channel/UCwqC_s6gcCVvG7NOge3qfAQ/
Offline
User avatar

spazsinbad

Elite 5K

Elite 5K

  • Posts: 22984
  • Joined: 05 May 2009, 21:31
  • Location: ɐıןɐɹʇsn∀¯\_(ツ)_/¯
  • Warnings: -2

Unread post25 Nov 2014, 21:10

X-35C & F-35C FCLP & Arrests NIMITZ Nov 2014

RAN FAA A4G Skyhawk 1970s: https://www.faaaa.asn.au/spazsinbad-a4g/ AND https://www.youtube.com/channel/UCwqC_s6gcCVvG7NOge3qfAQ/
Offline
User avatar

spazsinbad

Elite 5K

Elite 5K

  • Posts: 22984
  • Joined: 05 May 2009, 21:31
  • Location: ɐıןɐɹʇsn∀¯\_(ツ)_/¯
  • Warnings: -2

Unread post27 Nov 2014, 22:24

ONLY some woids from this excellent 6 page PDF article from Dec 2014 edition of Air International [NOW ATTACHED] are excerpted below.
Cats, Traps & a Rooster Tail
December 2014 Mark Ayton Air International

"[F-35C Aircraft] “...CF-03/‘SD73’ and CF-05/‘SD75’...

...DEVELOPMENTAL TESTER TEST DIRECTOR
Cdr Shawn Kern is the Director of Test and Evaluation for F-35 Naval Variants and the senior military member within the F-35 Integrated Test Force (ITF) based at Patuxent River. He leads a diverse team comprising 920 members from the US Government, the military and contractors responsible for developmental test of the F-35B and F-35C aircraft during the System Development and Demonstration phase. During DT I, Cdr Kern led the F-35 ITF, provided government oversight of carrier suitability testing and co-ordinated with the USS Nimitz’s captain, executive officers and other F-35 stakeholders.

He told AIR International: “Launch testing included minimum catapult end speed determination as well as performance and handling during high and low energy catapult launches and crosswind conditions at representative aircraft gross weights. Approach and recovery testing focused on aircraft performance and handling qualities during off-nominal recoveries in low, medium, high and crosswind wind conditions. Data and analysis from DT I will support the development of initial aircraft launch and recovery bulletins for F-35C carrier operations and Naval Air Training and Operating Procedures Standardisation (NATOPS) flight manual procedures. Test results from DT I will also influence follow-on developmental and operational testing required to achieve F-35C initial operational capability.”

Lt Cdr Ted Dyckman is a US Navy F-35 test pilot assigned to VX-23 based at Naval Air Station Patuxent River, Maryland: he made the second-ever arrested landing on a super carrier in aircraft CF-05 on November 3 and the first night-time landing on November 13 in CF-03. Speaking about the F-35C’s performance around the carrier, Lt Cdr Dyckman told AIR International: “Everything met expectations and there were no surprises. Going through the burble was a big unknown, but the airplane responded better than we thought it would.

“We saw that the aircraft could trap: the only true bolter was a power call by the Landing Signals Officer when the aircraft touched down long with the hook down but came around and made an arrested landing.

“When the weather started to deteriorate we had such confidence in how the aircraft was flying that we lowered the weather minimums to those used by the fleet. I knew that when I lowered the hook I was going to trap. That says a lot for the airplane.

“Because the autopilots and flying qualities are so good, the workload to fly the jet is reduced and we were confident enough to declare it ready for night-time traps. It flew very well behind the ship and I made two hook-down passes and two traps. It’s unheard of to conduct night ops on a type’s first period at sea.

“We accomplished everything we set out to do, which allows us to go to DT II and conduct maximum speed catapult shots and carry internal and external stores and asymmetric payloads.”...

...Flight testing was split into three phases: day carrier qualification (CQ) and flight deck crew familiarisation; the development of aircraft launch bulletins (ALB) and aircraft recovery bulletins (ARB). In addition DT I also included Logistical Test and Evaluation (LT&E). Subsets of each phase comprised:

Aircraft Launch Bulletins
• Military rated thrust catapult launches
• Minimum catapult launch end speeds
• Low, medium and high excess wind over deck (WOD) catapult launches
• Crosswind catapult launches
• Bow and waist catapult launches

Aircraft Recovery Bulletins
• Approach handling qualities (AHQ) of F-35C approach modes: delta flight path, approach power compensator (APC), and manual • Low, medium and high excess WOD recoveries
• Crosswind recoveries • Bolter performance Logistical Test and Evaluation
• Deck handling including taxiing, towing and tie-down
• Weapons loading
• Basic maintenance, including aircraft jacking and landing gear servicing
• Maintenance support

Preparations
Since the author’s previous visit to the F-35 ITF at Pax River in April the main test objectives completed over the summer were arrested landings, touch and goes (a training evolution also known as field carrier landing practice or FCLP) and a structural survey of CF-03. The latter was a methodical check of the aircraft to ensure it was structurally suitable to be flown aboard an aircraft carrier. The survey included testing engineering fixes made to the aircraft’s pitch pivot pin and nose wheel steering motor. Although precautionary, the survey was required because functionality problems had been discovered with each component during the F-35C’s developmental flight test programme. A subset of the structural testing performed on CF-03, known as a shake, was also completed on CF-05 to ensure it was also suitable for carrier trials. No issues were found.

One other pre-deployment test evolution was electromagnetic environmental effects (E3). This required CF-03 to spend two weeks in the shielded hangar at Pax River, to ensure that electromagnetic interference from the ship’s emitters did not affect any of the aircraft’s vital systems and cause them to shut down. The official E3 test report was completed on October 16 which cleared the aircraft to embark onboard the carrier.

All requisite carrier suitability testing was concluded on October 17 and the final FCLPs were completed at Pax River four days later.

One interruption to the test programme over the summer was caused by the temporary grounding order resulting from an engine fire on F-35A AF-27, serial number 10-5015, at Eglin Air Force Base, Florida on June 23. Each engine underwent a rigorous inspection process and because of the priority given to DT I, CF-03 was the first to be inspected, analysed and cleared back to flight: CF-05 followed....

...No modifications were required to the flight deck, not even the Jet Blast Deflectors (JBDs): hydraulic-controlled panels designed to divert hot aircraft exhaust during launches. The panels are raised in preparation for takeoff, protecting the flight deck and aircraft behind from the hot aircraft exhaust. Modification of the JBDs will be required for subsequent DT evolutions, when afterburner will be required to launch aircraft with heavier all-up weights than those used during DT I. Any changes implemented will alter the cooling path of the F-35’s exhaust plume, which interacts with the carrier’s decking differently from that of the twin-engined members of the Hornet family....

...Support Onboard and from Ashore
DT I was supported by a pre-production, nonfleet representative version of the Autonomic Logistics Information System known as ALIS 1.03. According to the F-35 Joint Program Office: “Standard ALIS functions were in place and used to support F-35C operations and maintenance onboard USS Nimitz. The functions were accessible via approved Department of Defense network and cyber security policies and authorisations similar to ALIS support for F-35B STOVL deployments to the USS Wasp (LHD 1)....

...Increased robustness in the aircraft’s control laws refers to:
• Pro-rotation during a catapult and bolter.
• Integrated Direct Lift Control which integrates the control surfaces such that wing camber is altered to increase or decrease lift, thus allowing glide slope changes to be made without a large change in engine thrust.
• Delta Flight Path, which is an innovative leap in aircraft flight controls, that commands the aircraft to capture and maintain a glide slope. The system greatly reduces the pilot’s workload, increases the safety margins during carrier approaches and reduces touchdown dispersion.

Wind Effects
Aircraft carriers are unique in that they have different wind effects that the pilot and the aircraft’s flight control laws must take into account. The overall wind effect is called the burble,...

...“We are evaluating how the control law handles through the burble. Data collected during DT I will now be used by the control law engineers for analysis and to improve our simulator modelling. Because the burble is such a dynamic and integrated wind system there are challenges to modelling it accurately. Future F-35 pilot training will benefit from this work,” said Cdr Wilson....

...We started making intentional errors in our approaches [off-nominal]. This allowed us to see how the aircraft’s flight control laws react to corrections input by the pilot and the effect of the burble while trying to make the corrections. “The pilot intentionally lines up [on approach] on either side of the landing area…starting either high or low, or flying fast or slow to see if there is enough time to input the correction and get back on centreline, on glide slope and on speed [flying a proper approach speed] prior to touch down. “As we fly off nominal approaches, if the LSO [landing signals officer] doesn’t see a timely correction or doesn’t feel that the pilot is going to land safely, he or she will wave them off.

“The LSO [who is located on a platform positioned 120ft (36.6m) from the end of the ship and 40ft (12.2m) from the centreline on the port side] is a pilot trained to observe the aircraft as it flies down the approach watching for deviation in pitch attitude using a camera that shows whether the aircraft is on or off centreline. Listening to the aircraft, the LSO is trained to recognise changes in rates of vertical and horizontal movement to ensure the aircraft is going to clear the ramp at the aft of the ship and recover safely aboard. The LSO plays a vital role in the safe recovery of aircraft aboard the ship.

“Getting aircraft back to the boat is our first concern: our second is [preventing] what we call a long bolter. This occurs if the pilot fails to correct a big deviation and lands well beyond the four-wire [the last arrestment cable along the deck]. For safety purposes any time an aircraft touches down on the deck, the pilot needs sufficient deck to derotate, and get the throttle back to mil[itary] power to fly away. There’s not enough time for the plane to de-rotate with a long bolter, which means it could still have downward direction so when [the aircraft] rolls off the front end of the boat it’s going to sink....

...evaluated approaches with crosswinds behind the ship out to 7kts....

...“We also evaluated approach handling qualities in low and high wind conditions: low is 10 to 20kt, nominal is 20 to 30kt and high is in excess of 30kt. The team’s goal for DT I was to gain as much data with cross winds and various head winds to allow us to start writing our aircraft launch and recovery bulletins.”

What Next?
Testing around the carrier gets more complicated with aircraft weight and asymmetry. On subsequent DT events the F-35 ITF will increase aircraft weight and asymmetry by loading stores on one side to create as much asymmetry as possible, which is the complicating factor. Cdr Wilson told AIR International that testing on subsequent DT events is going to look very similar but will evaluate heavier weights and asymmetric lateral weight differences.

OUTCOMES FROM DT I
• Flight test conducted in the operational environment.
• The F-35C demonstrated exceptional handling qualities throughout all launch and recovery conditions tested.
• All four test pilots rated the F-35C to be very easy to operate from the carrier. Arrested landings were consistent: the aircraft caught the optimal three-wire in the majority of the 102 traps. Pilot comments included: “I noticed the burble, but the aircraft just takes care of it”, “It makes flying the ball comfortable” and “This thing is a three-wire machine”....

...STATISTICS FROM DT I
Start date: November 3
Completion date: November 14
Flights: 33
Flight hours: 39.2
Catapult launches: 124
Touch-and-goes: 222
Arrested landings: 124
Bolters: 2 intentional with the hook down
Threshold test points completed: 100%”

Source: pp 42-47 Air International December 2014
Attachments
F-35CtestNIMITZnov2014 AirInternationalDec2014.pdf
(1.21 MiB) Downloaded 3381 times
RAN FAA A4G Skyhawk 1970s: https://www.faaaa.asn.au/spazsinbad-a4g/ AND https://www.youtube.com/channel/UCwqC_s6gcCVvG7NOge3qfAQ/
Offline
User avatar

spazsinbad

Elite 5K

Elite 5K

  • Posts: 22984
  • Joined: 05 May 2009, 21:31
  • Location: ɐıןɐɹʇsn∀¯\_(ツ)_/¯
  • Warnings: -2

Unread post02 Dec 2014, 00:51

IF unfamiliar with the whys and wherefores of how ordinary people become NavAv pilots (in the old USN) well - this is the way:

Buckeye T-2C FCLP & Carrier Quals New Pilots

RAN FAA A4G Skyhawk 1970s: https://www.faaaa.asn.au/spazsinbad-a4g/ AND https://www.youtube.com/channel/UCwqC_s6gcCVvG7NOge3qfAQ/
Offline
User avatar

spazsinbad

Elite 5K

Elite 5K

  • Posts: 22984
  • Joined: 05 May 2009, 21:31
  • Location: ɐıןɐɹʇsn∀¯\_(ツ)_/¯
  • Warnings: -2

Unread post02 Dec 2014, 17:48

Thanks 'SWP' for this link (on another 'blog'): [BEST READ at URL below]
SAC-D Hearing Opening Statement on the Joint Strike Fighter (F-35C) Chief of Naval Operations Admiral Greenert
19 June 2013 by jfmetzger

"...Today’s topic, for me the F-35C is really a key part of our future. It provides a unique and essential set of capabilities for our air wing and for our carrier strike group, effectively for the fleet. And it will dramatically enhance the near term and the future air wing capability immediately upon its integration....

...So to me Mr. Chairman the F-35C is designed to provide the capability we need and I look forward to working with this committee, with the Congress and with program committee to bring this into the fleet in an affordable rate, thank you."

Source: http://cno.navylive.dodlive.mil/2013/06 ... ter-f-35c/
RAN FAA A4G Skyhawk 1970s: https://www.faaaa.asn.au/spazsinbad-a4g/ AND https://www.youtube.com/channel/UCwqC_s6gcCVvG7NOge3qfAQ/
Offline
User avatar

spazsinbad

Elite 5K

Elite 5K

  • Posts: 22984
  • Joined: 05 May 2009, 21:31
  • Location: ɐıןɐɹʇsn∀¯\_(ツ)_/¯
  • Warnings: -2

Unread post03 Dec 2014, 12:19

How an approach to NIMITZ may have looked - via STENNIS: http://media.komonews.com/images/130401 ... nnis_2.jpg
"The USS John C. Stennis is seen in a March 3, 2013 Navy photo."
Attachments
STENNISapproach.jpg
RAN FAA A4G Skyhawk 1970s: https://www.faaaa.asn.au/spazsinbad-a4g/ AND https://www.youtube.com/channel/UCwqC_s6gcCVvG7NOge3qfAQ/
Offline

langbein

Newbie

Newbie

  • Posts: 8
  • Joined: 24 Aug 2013, 20:10
  • Location: NORWAY

Unread post05 Dec 2014, 00:09

Hi!

Thank you all for a great site. This is my first post here. Found this video on youtube.

Crew Interviews from F-35C Sea Trials

https://www.youtube.com/watch?v=d7VuysNHFIY

Looking good!

Regards,

Morten
Offline
User avatar

spazsinbad

Elite 5K

Elite 5K

  • Posts: 22984
  • Joined: 05 May 2009, 21:31
  • Location: ɐıןɐɹʇsn∀¯\_(ツ)_/¯
  • Warnings: -2

Unread post05 Dec 2014, 01:38

Thanks 'Morten', Great video - with extra not before seen scenes - turn down the volume on the initial music perhaps or turn it up to ELEVEN! :devil: Screenshot below shows weight board for catapulting at 46K lbs. Which is around the max arrested landing weight - makes sense when doing as many cats and arrests as possible for carqual etc. Den Dat HOOK - Capt'n (wot no crocodile - tick tock) & those northern lights for de catapult holdback (mistooken for a fire earlier). :devil:
F-35C Opt AoA: VX-23 'Salty Dogs' F-35C Update Paddles Monthly
Sept 2010 LCDR Ken “Stubby” Sterbenz VX-23 Ship Suitability Department Head

"...The max trap weight will be around 46k lbs, with an empty weight of about 35k lbs.
It will fly an on-speed AOA of 12.3° at 135-140 KCAS [Optimum AofA or Donut]...."

Source: http://www.hrana.org/documents/PaddlesM ... er2010.pdf (1Mb no longer available)

AND DA HOOK!

Just as an aside - to highlight the difference between NOW and in ye olden dayse:
RECOLLECTIONS OF AEROMEDICAL FLYING TRIALS
11 Mar 2014 Surg Cdr Herbert Ellis RN FAA

"...Next day we were off to visit Ark Royal [in a tandem METEOR without a hook]. What then took place warrants recording in the history books – Pat was the oldest man ever to have done a first ‘deck landing’. After an initial try, when I flew the aircraft from the back seat for a ‘touch and go’, Pat repeated the exercise himself a few times before we returned to Farnborough.

This met the Admiralty’ s requirements before participating in deck-landing. And here I quote……
‘No one must do a deck-landing until, either, he has completed a formal course in deck-landing or he has done a deck-landing.


Source: http://www.rafmuseum.org.uk/documents/R ... dicine.pdf (3Mb)
Attachments
F-35CweightBoard46K.jpg
METEORtouch&GoArkRoyalNoHook.jpg
F-35ChookNimitzDeck.jpg
F-35CholdbackLightsNIGHTcatFORUM.jpg
RAN FAA A4G Skyhawk 1970s: https://www.faaaa.asn.au/spazsinbad-a4g/ AND https://www.youtube.com/channel/UCwqC_s6gcCVvG7NOge3qfAQ/
Offline
User avatar

neptune

Elite 2K

Elite 2K

  • Posts: 2885
  • Joined: 24 Oct 2008, 00:03
  • Location: Houston

Unread post05 Dec 2014, 04:32

langbein wrote:..F-35C Sea Trials..



Thanks, this is why I keep coming back to this site!

:)
Offline
User avatar

spazsinbad

Elite 5K

Elite 5K

  • Posts: 22984
  • Joined: 05 May 2009, 21:31
  • Location: ɐıןɐɹʇsn∀¯\_(ツ)_/¯
  • Warnings: -2

Unread post05 Dec 2014, 05:11

From same video mentioned above - JUST THE DLs and ONLY THE DLs (mostly). Some in SLO MO and look at that last catshot. Bumpy Bumpy indeedy. AND.... some old USN TA-4J action for nugget CarQuals etc.


RAN FAA A4G Skyhawk 1970s: https://www.faaaa.asn.au/spazsinbad-a4g/ AND https://www.youtube.com/channel/UCwqC_s6gcCVvG7NOge3qfAQ/
Offline
User avatar

sferrin

Elite 5K

Elite 5K

  • Posts: 5306
  • Joined: 22 Jul 2005, 03:23

Unread post05 Dec 2014, 06:05

I think youtube killed your sound.

Yikes, that main gear is pretty scarey there at 1:10. How that compare to something like a Tomcat or Super Hornet?
"There I was. . ."
Offline
User avatar

spazsinbad

Elite 5K

Elite 5K

  • Posts: 22984
  • Joined: 05 May 2009, 21:31
  • Location: ɐıןɐɹʇsn∀¯\_(ツ)_/¯
  • Warnings: -2

Unread post05 Dec 2014, 06:50

Regarding sound in F-35C clip: To pre-empt Youtube offering to truncate any soundtrack not able to be online in a video youse can elect to just have the first ten seconds - so that is what you hear - going down the hard road by hilltop hoods.

The F-35C can bring back (MAX. Carrier Landing Arrest Weight) around 2,000 lbs more than the Super Hornet at similar airspeeds (at a rough guess on IAS - NATOPS will have those details). I would have to find a Tomcat F-14 NATOPS probably to answer that question. In the other long thread (LAKEHURST) as I recall there was a table of max.arrest.weights and approach speeds probably. Too long ago and too much information inbetween that I'll never need to remember to remember. :mrgreen:

Last edited by spazsinbad on 05 Dec 2014, 07:27, edited 2 times in total.
RAN FAA A4G Skyhawk 1970s: https://www.faaaa.asn.au/spazsinbad-a4g/ AND https://www.youtube.com/channel/UCwqC_s6gcCVvG7NOge3qfAQ/
PreviousNext

Return to F-35 milestones

Who is online

Users browsing this forum: No registered users and 2 guests